Energy, exergy and economic (3E) study on waste heat utilization of gas turbine by improved recompression cycle and partial cooling cycle. Issue 2 (1st June 2023) - Zhang, Lei
ABSTRACT: As the bottom cycle of gas turbine waste heat utilization, the S-CO2 cycle can enhance the power output capacity of the system. Based on the energy analysis of the recompression cycle and the partial cooling cycle for gas turbine waste heat utilization, the two cycles are improved from the matching of heat exchange flow of regenerator and heater in this paper. Under the same parameters, compared with the cycle before improvement, increase in heat source utilization rate and net power output of improved cycles is 45.69% and 39.31%, 43.54 MW and 35.43 MW, and the power consumption cost is decreased by 0.6106 $/kWh and 0.6289 $/kWh. However, as part of heat recovery inside the system is replaced by the heat of the heat source, the thermal efficiency is decreased by 10.43% and 8.7%, respectively. Variable parameter study is conducted on the two improved cycles to analyze the cycle characteristics from the perspective of energy, exergy, and economy (3E). The results showed that the improved recompression cycle has a high thermal power conversion capacity, higher system thermal efficiency and exergy efficiency and lower power generation cost, while the improved partial cooling cycle has higher waste heat utilization potential. However, the area of heat exchangers in both cycles tends to increase, which is not conducive to the compactness of the system.