Performance evaluation of a hybrid heating system combined a groundwater source heat pump with an existing fuel oil heater for a horticultural greenhouse. Issue 13 (21st October 2022)

• Record Type: Journal Article
• Authors: Zhou, Meili; Cai, Fei; Uenishi, Masahisa; Sekine, Yasumasa
• Is Part Of: International journal of green energy. Volume 19:Issue 13(2022)
• Page Start: 1404
• Page End: 1414
• Publication Date: 2022-10-21
• Subjects: Greenhouse -- hybrid heating system -- groundwater source heat pump -- energy saving -- co2 emissions reduction; Power resources -- Research -- Periodicals; Energy industries -- Periodicals; Energy development -- Periodicals; 333.79
• DOI: 10.1080/15435075.2021.2000415
• Languages: English
• ISSNs: 1543-5075

Abstract

ABSTRACT: This paper reports a new hybrid heating system (HHS) installed in a horticultural greenhouse to lower the impact of high and unstable fuel prices on the greenhouse operation cost, to save the energy necessary to heat the greenhouse, and to reduce CO2 emissions. The HHS consisted of a groundwater source heat pump system for basic heating and an existing fuel oil heater for peak heating. The performance of the HHS, including the fuel oil and energy savings, and CO2 emissions reduction, was evaluated based on measurements during a heating period from November 2014 through May 2015. The results show that, comparing with only using the existing fuel oil heater to heat the greenhouse, the HHS can save 74.4% fuel oil and 22.8% energy, and reduce 35.5% CO2 emissions. In order to further increase the performance of the HHS, the operating control of the HHS, indoor hot air delivery system, and local thermal insulation of the greenhouse were improved. Performance evaluation based on measurements from November 2015 through May 2016 shows that the improved HHS can save 88.0% fuel oil and 35.9% energy, and reduce 48.7% CO2 emissions, which are significantly higher than those of the HHS before improved. Moreover, the comparison indicates that the performance of HHS was almost not changed with three different groundwater pumping rates tested herein. The proposed HHS is particularly suitable for transforming conventional fossil heating systems of horticultural greenhouses into a more energy-saving and thus sustainable heating system with a comparatively low initial cost.