A novel Dy3+-activated single-phase white light-emitting phosphor for solid-state lighting. (10th November 2021)

• Record Type: Journal Article
• Authors: Kuang, Meng; Li, Junhao; Zhang, Jinjun; Ding, Jianhong; Zhang, Ziwang; Huang, Kangrong; Yang, Nan; Zhang, Ziheng; Yang, Mingming; Ni, Haiyong
• Is Part Of: New journal of chemistry. Volume 45:Number 45(2021)
• Page Start: 21066
• Page End: 21073
• Publication Date: 2021-11-10
• Subjects: Chemistry -- Periodicals; Chimie -- Périodiques; 540
• DOI: 10.1039/d1nj04570a
• Languages: English
• ISSNs: 1144-0546

Abstract

Abstract : The doping of Dy 3+ in the SCB host is capable of producing blue, yellow and red emissions, and therefore, SCB:Dy 3+ can serve as a single-phase white-light-emitting phosphor for solid state lighting. Abstract : The radius of trivalent scandium ions is much smaller than those of other rare earth ions and thus research studies targeting the substitution of the scandium site with other light-emitting rare earth ions are rarely reported. In our present work, special attention is paid to the effect of Dy 3+ doping on the crystal structure, atomic site occupancy and luminescence properties of the ScCaBO4 host as Dy 3+ often serves as an individual activator for single-phase white light-emitting phosphors. Herein a series of ScCaBO4 :Dy 3+ phosphors were prepared by solid-state reactions. The phase composition was recorded by X-ray diffraction analysis and XRD refinement reveals that a pure phase could be maintained even when the Dy 3+ concentration reaches 11%. Scanning electron microscopy (SEM) was utilized to observe the morphology and EDS mapping was used to investigate elemental distribution. The luminescence performances of the phosphors were investigated using UV-vis diffuse reflectance spectra, steady-state excitation and emission spectra and also transient luminescence decays. Dy 3+ luminescence can be ascribed to its 4 F9/2 → 6 H15/2, 6 H13/2 and 6 H11/2 transitions, producing blue, yellow and red emissions. The Dy 3+ concentration was further optimized at 3%, at which the CIE coordinates and fluorescence lifetimes were (0.425, 0.413) and 0.546 ms, respectively. Thermal quenching studies of the ScCaBO4 :0.03Dy 3+ phosphor show that Dy 3+ luminescence at 400 K can maintain 60.91% of its initial value measured at room temperature. All the results indicate that the ScCaBO4 :Dy 3+ inorganic phosphors could be a promising single component phosphor for near-UV chip based WLEDs.