Effect of different excess air ratio values and spark advance timing on combustion and emission characteristics of hydrogen-fueled spark ignition engine. (20th September 2019)

• Record Type: Journal Article
• Authors: Lee, Jeongwoo; Park, Cheolwoong; Bae, Jongwon; Kim, Yongrae; Choi, Young; Lim, Byeungjun
• Is Part Of: International journal of hydrogen energy. Volume 44:Number 45(2019)
• Page Start: 25021
• Page End: 25030
• Publication Date: 2019-09-20
• Subjects: Air excessive ratio (excess air ratio) -- Back-fire -- Hydrogen-fueled -- Lean mixture condition -- Spark advance timing -- Spark ignition engine; Hydrogen as fuel -- Periodicals; Hydrogène (Combustible) -- Périodiques; Hydrogen as fuel; Periodicals; 665.81
• DOI: 10.1016/j.ijhydene.2019.07.181
• Languages: English
• ISSNs: 0360-3199

Abstract

Abstract: This study investigated the effect of varying the spark advance timing and excess air ratio (air excessive ratio; λ) on the combustion and emission of nitrogen oxide (NOx) in a hydrogen-fueled spark ignition engine under part load conditions. The engine test speed was fixed at 2, 000 rpm and the torque condition was 60 Nm. Excess air ratio was varied from the stoichiometric (λ = 1) to the lean mixture condition (λ = 2.2) by throttling. The spark advance timing was controlled to determine the maximum brake torque timing (MBT) for each excess air ratio value. Subsequent to the determination of the spark advance timing for MBT, the spark timing was varied from MBT timing to top dead center. Based on the results, it is concluded that the leanest mixture condition (λ = 2.2) with MBT spark timing exhibited the highest brake thermal efficiency of 34.17% and the NOx emissions were as low as 14 ppm. Highlights: Heat release from the residual gas follows the main combustion of hydrogen mixture at λ = 1. Thermal efficiency increased up to 34% with pumping loss reduction at λ = 2.2. Combustion loss does not exceed 0.32% and maximum unburned hydrogen occurred at λ = 1. The lowest NOx emissions are 14 ppm and 0.07 g/kWh at λ = 2.2.